Term
| Personnel Required- Normal Tow |
|
Definition
| 6. 1 brake rider, 1 move directro, 1 tow tractor driver, 1 tail walker, 2 wing walkers |
|
|
Term
| Personnel Required- icee conditions |
|
Definition
| 8. 1 brake rider, 1 move directro, 1 tow tractor driver, 1 tail walker, 2 wing walkers, 2 chaulk walkers |
|
|
Term
|
Definition
| Towing with flat tires. IAW GAI-000. Must meet condition 4 to have zero limitations. |
|
|
Term
| What to do with jammed flight controls? |
|
Definition
Instruct to hold in position and maintain light pressure on the affected flight control surface
contact QA/WC/SAFETY |
|
|
Term
Jammed flight controls?
If source of jam is found? |
|
Definition
| Issue discrepancy WO, repair. Sign off conditional and refer it to the repair WO. |
|
|
Term
Jammed flight controls?
Cannot find source of the jam who can autherize the A/C release? |
|
Definition
| CO, usually a verbal, or XO/OIC if designated in writing can release if source is not found. than log book entry |
|
|
Term
| How long is the daily/Turn around good for? |
|
Definition
Daily good for 72 Hours.
Turn around good for 24 Hours. |
|
|
Term
|
Definition
| Less than or equal to 16 oz per flight hour. |
|
|
Term
| When do you monitor oil consumption? |
|
Definition
|
|
Term
| At what point do you R/R an engine for oil consumption? |
|
Definition
| 18 or more oz per flight hour. |
|
|
Term
| What are the limitations to servicing the engines after a flight or turn? |
|
Definition
| 5 min wait and must be service within 30 mins |
|
|
Term
| What happens if you miss your window for servicing (oil)? |
|
Definition
| max motoring on each engine to warm up oil; than, service. |
|
|
Term
| what are the wind limitations on engines cowling doors? |
|
Definition
|
|
Term
| what needs to be done if the engine exceeds 16 oz an hour? (leak) |
|
Definition
| Verify math, determin leak or consumption. If leak than write maf and correct, highlight oil log and annotate JCN. |
|
|
Term
| What needs to be done if the engine exceeds 16 oz an hour? (consumption) |
|
Definition
| Service engine, complete 45 min penalty run, if less than 16 no action, 16-18 monitor greater than 18 R/R engine. |
|
|
Term
| When are disconnected generators hours logged? When does it matter? |
|
Definition
When it is greater than 10 hours.
when it exceds 75 disconnected hours total, than you R/R generator. |
|
|
Term
| Weight and balance, what is required and when? |
|
Definition
| Required signed chart C (Constant) and a new form F for each flight, also required when ever you jack an aircraft. |
|
|
Term
|
Definition
| Ask if they are done, ensure proper debriefs are completed with work center either way. |
|
|
Term
De-ice procedures?
Snow and ice limits |
|
Definition
FWD to AFT INBD to OTBD.
0" on top of wing 1/8" on bottom. |
|
|
Term
| De-ice procedures where do we do it? |
|
Definition
|
|
Term
| De-ice procedures who is involved? |
|
Definition
base enviorment
hazmat
line Sailors that are qualified |
|
|
Term
| De-ice procedures what Paper work required? |
|
Definition
| De-ice report due within 8 hours, how much was used and picked up from the tennet, and what truck was utilized. |
|
|
Term
| De-ice procedures who is in-charge? |
|
Definition
| Air craft Commander and FE until job completed. |
|
|
Term
| What do you do for snow and severe weather. |
|
Definition
| plug and cover and tape door, ensure all flyable aircraft are ready to go. If snow contact base operations reguarding removal of snow. |
|
|
Term
| Aircraft jacking what is the required minimum fuel load? What is the Max aircraft weight? |
|
Definition
|
|
Term
| What is the max wind speed for alloable jacking aircraft on the ramp? |
|
Definition
| 20 knots if moving the Jet up or down, 25 knots if already on jacks. |
|
|
Term
|
Definition
| accecptance, fixed flight control surfaces, multiple engines, fuel or major componets, (2) natops, rework, movabale flight controls, 30 days no fly, discrepancies found during phase that require FCF, attitude sorces |
|
|
Term
| How many attitude sorces does an E-6 have and how many have to be r/r to require an FCF? |
|
Definition
four, 3 IRUs and a standy by gyro.
3 or more have to be R/R to warrent an FCF. |
|
|
Term
| What are the requirement for tycom approval for cann items? |
|
Definition
| CAD's and between squadrons. |
|
|
Term
| What are the requirement for CNAF approval for cann items? |
|
Definition
| OOR and NMC for over 120 days. |
|
|
Term
| Where are high power turns allowed? |
|
Definition
| any spot except T4 or T7. |
|
|
Term
| Who is required for low power turns. |
|
Definition
| road guards (2) posted behind aircraft on road. |
|
|
Term
| Where can low power maintenance turns be performed? |
|
Definition
|
|
Term
Phase?
when are they issued? |
|
Definition
600 hours on 4 cycles 2400 hours total
Plus 10% an additional 10% if wing approves and an additional 10% with CNAF approval. |
|
|
Term
Phase/specials
What are the deviations? |
|
Definition
phase / hourly 10%
special inspections +/- 3 days
structial life limited comp -10% iaw pmic |
|
|
Term
| Who is the approvaing authority of MESM? |
|
Definition
|
|
Term
|
Definition
|
|
Term
Project Priority codes
AKO |
|
Definition
| "Z" High Priority NMC Scir Impacting |
|
|
Term
Project Priority codes
AK7 |
|
Definition
| "C thru L" PMC Scir Impacting |
|
|
Term
Project Priority codes
AK1 |
|
Definition
|
|
Term
Project Priority codes
730 |
|
Definition
| Out Of Reporting Aircraft |
|
|
Term
Project Priority codes
ZA9 |
|
Definition
|
|
Term
Project Priority codes
Z09 |
|
Definition
|
|
Term
Project Priority codes
001 |
|
Definition
| FOR SCIR IMPACTING GRIPES |
|
|
Term
Project Priority codes
004 |
|
Definition
| NON SCIR IMPACTING GRIPES |
|
|
Term
|
Definition
|
|
Term
| When are high time mafs written? |
|
Definition
| 15 days out but can be issued anytime |
|
|
Term
| When are high time parts ordered |
|
Definition
|
|
Term
| What is the project pri codes for high time? |
|
Definition
| with in 15 days ZA9-04, after 15 days, what ever the EOC code for WO would be. |
|
|
Term
|
Definition
| meeting on the 15th issued by the 25th, |
|
|
Term
MMP
What information is in the mmp? |
|
Definition
| training,important people, qualifications, signature authoritys,360day inspections,high time components, forced removals, TD's, compass calibration, phase, special inspections,locally required info |
|
|
Term
| What is a maintenance request, where is it found and who gets it? |
|
Definition
| it is a depot level WR and located on the N4 website and the n4 program manger + all of back office gets it. |
|
|
Term
Hyd samples
when are they needed? |
|
Definition
| accecptance, anytime you R/R a metal producing component? |
|
|
Term
Hyd samples
what classifications are required? |
|
Definition
| 3 for se and 5 for aircraft |
|
|
Term
Hyd samples
what are the two types of test? |
|
Definition
| patch and pod, pod is the preferred method. |
|
|
Term
| What is required for buyback? |
|
Definition
| buy back paper work, daily, ADB correct, hard card item updates, AIR, QA verify interior clean, X30 wo back to the W/Cs |
|
|
Term
| What is required for a sell? |
|
Definition
| EAL, daily/turnaround, ADB complete, special near due, high time near due, interior clean, X30 weekly CP, 360 days |
|
|
Term
Fuel cell maintenance
What fule can be used in any hanger |
|
Definition
|
|
Term
Fuel cell maintenance
Where is JP4/8 authorized for fuel cell work? |
|
Definition
|
|
Term
Fuel cell maintenance
What three mafs have to be cut inorder to do Fuel cell maintenance? |
|
Definition
120 fuel cell repair
220 disconnect batteries
QA post fod maf |
|
|
Term
Fuel cell maintenance
How long do you have to wet soak JP4/8 aircraft with JP5? |
|
Definition
|
|
Term
Fuel cell maintenance
How much fuel should be left after defule is completed? |
|
Definition
|
|
Term
Fuel cell maintenance
How long are EA certs good for? |
|
Definition
| As long as the EA makes them not to exceed 12 hours. |
|
|
Term
Fuel cell maintenance
What is the last action during fuel cell maintenance? |
|
Definition
|
|
Term
Tires
How do you change nose tires? |
|
Definition
|
|
Term
Tires
How Do you change Main mounts? |
|
Definition
| Changed one at a time when they exceed their wear limits |
|
|
Term
Tires
Can an aircraft be towed/taxied with a blown tire? |
|
Definition
Yes.as ong as they meet the condition four in the GAI
CADDY CORNER ONE TIRE PER SIDE |
|
|
Term
Tires
What has to be on the tire S/O? |
|
Definition
NDI, Torques, anti skid
cotter keys and tire pressure |
|
|
Term
| Tires.What is the proj/pri for tires ordered on the rack outside maintenance control? |
|
Definition
|
|
Term
Engine change MAFS / Conditionals
What conditionals are required? |
|
Definition
| strut inspection, card 117 fod inspection. |
|
|
Term
Engine change MAFS / Conditionals
Who do you contact for a new engine? |
|
Definition
| DRS they will need hours of the old engine and cycles, and close out oil consumption sheets in ADB. |
|
|
Term
Engine change MAFS / Conditionals
does the engine need preservation? |
|
Definition
| Prior to removal of engine in OMMA preserve the engine. |
|
|
Term
Engine change MAFS / Conditionals
Who needs FOMs? |
|
Definition
| 120 for indb engines for hyd pumps, 220 for wire harnesses |
|
|
Term
Engine change MAFS / Conditionals
SE? |
|
Definition
| always ensure that the calibration dates are good to go prior to starting the evolution |
|
|
Term
Engine change MAFS / Conditionals
what has to be completed when a new engine is installed? |
|
Definition
| depreservation, trim checks, and add new oil consumption sheets |
|
|
Term
Engine change MAFS / Conditionals
What do you do with the phase? |
|
Definition
| marry up the engine phase inspections |
|
|
Term
| How many SRC cards are listed in the log book |
|
Definition
|
|
Term
| FOD / Missing tool besides a missing tool what other 4 conditions must a card 117 FOD inspection be issued? |
|
Definition
Engine T/R R/R, Flight control maintenance, Fuel cell maintenance
Depot /Field lelve Maintenance |
|
|
Term
| Who releases the AC if a tool is not found? |
|
Definition
|
|
Term
| If a tool is lost while deployed and check list is completed by aircrew what do you do upon return to home base? |
|
Definition
|
|
Term
| When is a log book entry made for unrecovered missing tools? |
|
Definition
|
|
Term
| What are the procedures for a mishap? |
|
Definition
| Refer to checklist in maintenance control (red Book) |
|
|
Term
| What responsibilities do we have has maintennace controllers? |
|
Definition
| If you released the jet, find a replacement and remove yourself from the desk. |
|
|
Term
| Inflight parts requests, what do we need to get from the crew? |
|
Definition
| WUC, EOC, PN and where the plane is going. |
|
|
Term
| What is required for a VIP tour? |
|
Definition
interior clean,seat covers,seat belts,lav serviced,windows are clean
airstairs both fwd and aft,ACE/heater if required,Fancy engine covers |
|
|
Term
| What is required for deployable aircraft? |
|
Definition
| airstairs fwd and aft,interior clean, s/o weekly CP,have AZs issue weekly x30 cp,Lav serviced,windows clean,potable water serviced |
|
|
Term
| How many touch and gos constutes a landing? |
|
Definition
|
|
Term
|
Definition
| No fuel, LOX or people on aircraft |
|
|
Term
|
Definition
| Ensure all flyable aircraft have dailys, TA and min 80k on board |
|
|
Term
|
Definition
| No fuel or LOX No work on top of aircraft |
|
|
Term
|
Definition
| No fuel or LOX , no one on flight line period |
|
|
Term
|
Definition
| Plug and cover and call base ops for snow removal as required. |
|
|
Term
| Which three conditionals do not require a log book entry? |
|
Definition
| Post AR, LTWA re routing and FOD inspections |
|
|
Term
| When do you issue condtional inspection 88/89 a/c exceeding inflight limitations, flap down |
|
Definition
when an aircraft exceeds maxium speed limitations
exceeds acceleration limitations
severe/unusual flutter or vib
severe/unusual buffet
severe/unusual maneuver
severe/unusual turblance
severe/unusual buffet or stick shaker |
|
|
Term
| When do you issue condtional inspection 90/91 inflight limitations? |
|
Definition
when an aircraft exceeds maxium speed limitations
exceeds acceleration limitations
severe/unusual flutter or vib
severe/unusual buffet
severe/unusual maneuver
severe/unusual turblance
severe/unusual buffet or stick shaker |
|
|
Term
| When do you issue condtional inspection 92/94 landing gross weight exceeding airframe? |
|
Definition
|
|
Term
|
Definition
drain potable water
plug and cover aircraft
window and doors secured taped if required, move all se in hanger |
|
|
Term
| Who can authorize the dead dates of cads to be extended? |
|
Definition
|
|
Term
|
Definition
| At the end of the month they drop in. |
|
|
Term
| What is the max wind limitation for nose radome? |
|
Definition
|
|
Term
| What do you do if winds are in excess of 65 knots? |
|
Definition
| Turn aircraft into wind, with max fuel and flaps up. |
|
|
